1977 Chrysler Cordoba Base Hardtop 2-door 6.6l on 2040-cars

Auto blog

NHTSA investigating power modules on Chrysler Group SUVs and minivans

The Center for Auto Safety is officially petitioning the National Highway Traffic Safety Administration to begin scrutinizing alleged problems with the totally integrated power module (TIPM) on about 24 Chrysler Group SUVs and minivans. The advocacy group claims that the part's failure can cause affected vehicles to stall or not start at all. NHTSA is still looking into the accusations and deciding whether a full investigation is actually warranted.
The CAS petition claims at least 70 TIPM failures, but according to NHTSA, six of the complaints are for models that don't have the modules. In 34 of the reported cases, the vehicles refused to start, and in 17 of them the engine stalled. There were also two allegations of smoke and one of a fire. However, none of these affected airbag deployment or resulted in a crash.
This petition isn't the first TIPM-related problem for Chrysler Group. A recent report in the New York Times alleged that it found 240 complaints potentially related to the issue on NHTSA's website alone. In September, the automaker also recalled 230,760 examples worldwide (188,723 in the US) of the 2011 Jeep Grand Cherokee and Dodge Durango replace the fuel pump relay circuit inside of the TIPM-7 with one external to the unit. The original part could allegedly cause the models to stall without warning. Even earlier, the company also recalled about 80,000 examples of the Jeep Wrangler and Dodge Nitro in 2007 to have the module reprogrammed.

Hot sales have Detroit automakers shortening summer shutdowns

Back in May, there was speculation that the Detroit Three automakers would maintain or perhaps even extend their traditional summer shutdowns, mostly due to a bitingly cold winter that saw below-freezing temperatures infiltrate the southernmost reaches of the US, putting a chill on auto sales. Now, though, the numbers are in, and thanks to some promising sales figures, it looks like some domestic line workers are going to be working clear through July, in some cases.
According to Automotive News, Ford has slashed its traditional two-week hiatus for factory workers in half at four of its plants, while both Chrysler and General Motors will keep factories running nonstop (two plants in Chrysler's case and a third of GM's factories).
This is, as we said, thanks to some positive numbers. Chief among those is the Seasonal Adjusted Annual Rate, which was at an eight-year high of 17 million units. Individual figures were less promising. GM, embroiled in its recall scandal, still saw a one-percent increase while Ford dropped six percent in year-over-year sales. Chrysler was the big winner, though, with a nine-percent jump in June.

Is it time for American carmakers to give up on dual-clutch transmissions? [w/poll]

Last week, in the midst of Detroit's first days seeking relief in Chapter 9 of the bankruptcy code, Automotive News contributor Larry P. Vellequette penned an editorial suggesting that American car companies raise the white flag on dual clutch transmissions and give up on trying to persuade Americans to buy cars fitted with them. Why? Because, Vellequette says, like CVT transmissions, they "just don't sound right or feel right to American drivers." (Note: In the article, it's not clear if Vellequette is arguing against wet-clutch and dry-clutch DCTs or just dry-clutch DCTs, which is what Ford and Chrysler use.) The article goes on to state that Ford and Chrysler have experimented with DCTs and that both consumers and the automotive press haven't exactly given them glowing reviews, despite their quicker shifts and increased fuel efficiency potential compared to torque-converter automatic transmissions.
Autoblog staffers who weighed in on the relevance of DCTs in American cars generally disagreed with the blanket nature of Vellequette's statement that they don't sound or feel right, but admit that their lack of refinement compared to traditional automatics can be an issue for consumers. That's particularly true in workaday cars like the Ford Focus and Dodge Dart, both of which have come in for criticism in reviews and owner surveys. From where we sit, the higher-performance orientation of such transmissions doesn't always meld as well with the marching orders of everyday commuters (particularly if drivers haven't been educated as to the transmission's benefits and tradeoffs), and in models not fitted with paddle shifters, it's particularly hard for drivers to use a DCT to its best advantage.
Finally, we also note that DCT tuning is very much an evolving science. For instance, Autoblog editors who objected to dual-clutch tuning in the Dart have more recently found the technology agreeable in the Fiat 500L. Practice makes perfect - or at least more acceptable.