Ford F-250 on 2040-cars

Auto blog

Ford issues six recalls covering 101,000 vehicles for multiple issues

Ford is announcing six separate recalls for a variety of issues affecting a dozen models and a total of 100,610 vehicles in North America. However, according to Ford spokesperson Kelli Felker, "None of them have caused accidents or injuries." Half of them cover fewer than 1,000 cars.
The largest recall covers 92,022 North American examples (about 83,250 in the US) of some models of the Ford Taurus, Lincoln MKS, Ford Interceptor, Flex and Lincoln MKT from the 2013 and 2014 model years; the 2012-2014 Edge and the 2014 Lincoln MKX. All of them have a potential issue with the halfshaft on the right side that might not be fully seated and could move outward over time. If it shifts too far, the models may no longer be able to drive, and the condition could also allow the vehicles to roll away, even when in Park. Dealers will inspect the shaft to make sure it's seated and will replace the part if necessary.
The next-largest recall covers 5,264 North American examples (4,867 in the US) of the Ford F59 Commercial Stripped Chassis from the 2011-2014 model years. It's possible that an electrical junction box can corrode in areas with salty roads and short circuit. The problem could potentially cause a fire. Dealers will replace the box with an improved design.

Ford recalls 83k Taurus and crossover models for halfshaft issue

Ford and the National Highway Traffic Safety Administration have issued a recall for some 83,250 vehicles in the US, for an issue with halfshafts. More specifically a "halfshaft retention circlip" might not have been properly installed on affected vehicles, with the result being halfshafts that may move improperly or disengage completely from the linkshaft while driving. The NHTSA release also notes that the issue may occur "without prior warning" which obviously factors in to the timeliness of getting this checked.
Should the halfshaft disengage, a few troubling things could happen. If it occurs while driving, power from the engine will no longer be transmitted to the wheels. And, if the vehicle is parked without the parking brake applied after disengagement of the circlip, vehicles may roll away even if they're transmissions have been placed in "Park."
Affected vehicles are as follows: Ford Edge and Lincoln MKX crossovers from model years 2012 to 2014; Ford Taurus and Lincoln MKS sedans from model years 2013 to 2014; Ford Flex and Lincoln MKT vehicles from model years 2013 to 2014.

Ford issues four recalls covering 163k vehicles

Recalls! 2014 will be forever remembered as the year that automakers went recall crazy, with millions and millions of vehicles adding up to crush previous recall records well before the end of the year. Adding to that tally is Ford, which announced a call-back for 163,000 vehicles.
Leading that charge are the 2.0-liter, EcoBoost four-cylinder engines of the Ford Focus ST and Ford Escape. 160,000 of the 2013 and 2014 models have bad wiring harnesses that can disrupt the signals traveling to the powertrain control module. That, in turn, could lead to a check engine light, reduced power and stalling. Notably, Ford hasn't recalled any other vehicles that feature the 2.0 EcoBoost, such as the Fusion, Taurus or Explorer.
While the Focus ST and Escape constitute the vast majority of recalled vehicles, they aren't the only problem children in the Ford family. 1,300 Transit passenger vans from model year 2015 were recalled due to brake fluid leaks, while another 600 Transit cargo variants were recalled after Ford discovered the windowless sliding doors could come open in the event of a side-impact crash. Dealers will replace the sealing washers on the passenger variants and add a reinforcement plate on the cargo models, The Detroit News reports.