2011 Hyundai Sonata Se Sedan 4-door 2.4l on 2040-cars

Auto blog

Hyundai to build test facility at N"urburgring

It looks as if Hyundai is set to build a test facility at the famous Nürburgring. Carscoop reports the Korean automaker has commenced construction on a 10,000-square-foot test center with access to the lengthy German track. Hyundai says the $7.3 million facility will help the company focus on improving the ride and handling of its vehicles through extensive research and development.
Sounds like a plan to us. While we've seen Hyundai vehicles improve on many fronts over the past few years, the company continues to struggle with suspension refinement compared to its Japanese, German and domestic rivals.
Automakers routinely flock to the Nürburgring for testing and development thanks to the track's unusual attributes. With a variety of surfaces, banking, turns, elevation and even weather, the circuit offers engineers the ability to put a vehicle through its paces in a wider range of conditions than most facilities.

Hyundai, Kia recall 270,000 cold-weather state vehicles over rust

Hyundai has announced plans to recall 240,000 Sonata and Azera models registered in the northern United States over corrosion caused by the use of road salt. Exposure to the salt can cause rust to form (we know, basic chemistry here), and that the corrosion can change the alignment of the rear wheels, according to Reuters.
Sonatas from the 2006 to 2010 model years, built between March 1, 2005 and January 21, 2010, and Azeras from the 2006 to 2011 model years, built between September 27, 2005 and November 22, 2010, are covered only if they were registered in the following states: Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and Washington, DC. So basically, every state from the Midwest, to the central Atlantic coast, to New England. It is unclear exactly how many Sonatas or Azeras make up the 240,000 total number.
Hyundai is also recalling 20,300 of its 2013 Santa Fe Sports, while sister company Kia is recalling 9,345 2014 Sorentos. This second recall only covers Santa Fe Sport and Sorento models with the base, 2.4-liter engine and front-wheel drive. Apparently, the front axle driveshaft can develop cracks and separate.

NHTSA closes investigations into Ford Taurus, Hyundai Santa Fe

Ford and Hyundai are out from under the scrutinizing eyes of the National Highway Traffic Safety Administration after the government agency said it was closing investigations against both automakers over vehicle safety concerns.
Ford was being investigated for reported damaged speed control cables on Ford Taurus (shown above) and Mercury Sable models, both built between 2000 and 2003. Vehicles with the company's Duratec engines allegedly failed to allow owners to brake as expected. Owners lodged 100 complaints and were involved in five accidents, according to NHTSA records. The American automaker responded to the reports, and on June 21 of this year, said that it would inspect and repair all affected vehicles, regardless of the mileage.
Hyundai was under investigation for a reported loose fastener on the steering shaft of its 2011 Santa Fe (shown in the gallery below). After NHTSA launched its inquiry, the Korean automaker responded with its own investigation that yielded four affected vehicles. Following the inspection of 680 vehicles at its assembly plant, Hyundai said the issue was due to employee error and that no further defects have been found.