2002 Jeep Wrangler X Sport Utility 2-door 4.0l on 2040-cars

Auto blog

Chrysler recalling over 200k vehicles across its brands

With more than 200,000 units across six separate recalls and almost all of its brands, it appears that Chrysler has officially jumped headfirst into the recall pool this month. The National Highway Traffic Safety Administration has issued three official recalls for the automaker, and The Detroit News is reporting that the automaker itself has announced three more.
The biggest of the recalls applies to about 120,000 Dodge Charger, Dodge Challenger and Chrysler 300 models for 2011 and 2012 due to faulty wiring harnesses for the seat-mounted side airbags, which could lead to these airbags not deploying in the event of a crash. A little more than 60,000 two-wheel-drive versions of the 2007-2008 Dodge Nitro and 2008 Jeep Liberty SUVs are being recalled due to a heat shield that could cause the driveshaft to break, which if that isn't bad on its own, could then hit underneath where the airbag sensor is mounted, causing the airbags to deploy. Wrapping up NHTSA's recall notices, about 20,000 Jeep Patriot and Jeep Compass models for 2012 are also being recalled due to a problem with the fuel tank transfer tube that could lead to the vehicle stalling. The LX car recall campaign is going into effect this month, while the other two will start next month - all three notices are posted below.
In addition to the official NHTSA recalls, The Detroit News is also reporting that Chrysler is recalling more than 16,000 Ram trucks and a small number of Dodge Dart sedans. Around 6,500 2013 Ram 1500 trucks will be recalled due to an improper adjustment of the parking brake cable from the factory, while 7,000 Cummins-powered 2013 Ram Heavy Duty trucks are being recalled due to an engine cover that does not have as much heat resistance as it is supposed to. Finally, a total of 46 Dodge Dart sedans are being recalled due to a problem with the brake calipers and/or parking brake.

NHTSA closes book on Jeep 'trailer hitch' recall after all

After much debating and hand-wringing, the National Highway Traffic Safety Administration now says it has "no reservations" with Chrysler's plan to recall certain Jeep Liberty and Grand Cherokee models over concerns that their fuel tanks, which are located behind the rear axle, could rupture or leak in the event of a rear impact. The longstanding argument between the two entities saw Chrysler openly defy the Feds after a request to recall 2.7 million units back in June.
Chrysler's "voluntary campaign" will instead see it recall 1.56-million 1993-2004 model year Grand Cherokee SUVs, along with 2002-2007 Liberty models. Affected vehicles will get a trailer hitch installed free of charge, which Chrysler says will provide an additional degree of protection for the fuel tanks in the event of a crash. Jeeps with Mopar-branded hitches or hitches that were installed at the factory aren't affected by this recall.
Chrysler's argument throughout this battle has been that the Jeeps in question are no more susceptible to fires than comparable vehicles from the same time period, a position that NHTSA has seemingly arrived at as well. "Those vehicles performed at a rate similar to their peers. That is the keystone analysis as to whether something poses an unreasonable risk to safety," said outgoing NHTSA boss David Strickland during an interview with the The Associated Press.

Chrysler taking big risk snubbing NHTSA

Maker Insists Feds Overstate Risk Of Fires With Grand Cherokee, Liberty Models
It's not often that recall stories make it above the fold, in that old newspaper parlance, but when one shows up as the lead story on the network evening news programs, you know it's something big.
And so it is with Chrysler snubbing its nose at a request by the National Highway Traffic Safety Administration to recall 2.7 million Jeeps the feds insist are at risk of potentially catastrophic fuel tank fires in a rear-end collision.