2008 Jeep Wrangler Unlimited Sahara 4x4 Sport Utility 4-door 3.8l on 2040-cars

Auto blog

Chrysler investigating complaints of vehicles with faulty power modules

Chrysler owners are hopping mad after experiencing a series of electrical gremlins in some of the company's vehicles. Issues range from mere annoyances - windows rolling down and radios turning off of their own accord - to serious safety issues, with headlights that randomly shut off at night and cars that stall and refuse to start.
The issues are being blamed on the total integrated power module, which can cost up to $1,000 for customers to replace. This, of course, has led to a hefty batch of complaints to the National Highway Traffic Safety Administration, with 240 owners expressing their displeasure so far. Another site, CarComplaints.com, has registered over 300 complaints relating to the 2010 to 2011 Jeep Grand Cherokee and Dodge Durango, alone, according to The New York Times.
Chrysler has acknowledged that it's investigating the complaints and is analyzing the faulty TIPMs, but that isn't quite enough for customers of the affected vehicles. The newspaper has snagged a few of the more harrowing tales with the electrically challenged Chrysler products, culled from the NHTSA complaints.

AEV Jeep Wrangler Unlimited Rubicon

After their rented 2007 Hummer H3 failed them during the brutal Rallye Aicha des Gazelles in Morocco, Amy Lerner and her sister Tricia Reina were on a quest to find the most capable production off-roader for their next competition - they chose a 2012 Jeep Wrangler Unlimited Rubicon. Their next mission was to find a company with the competence to configure it to win. After poring over Internet forums and perusing countless magazines for an outfitter who could meet their demanding requirements, they sent their bright orange JK ("Crush" is the official color) to American Expedition Vehicles (AEV) for some modifications.
The Michigan-based team at AEV kept the Jeep's 3.6-liter V6 and automatic transmission stock, but replaced the hood with a tall AEV Heat Reduction Hood and added an AEV Snorkel Kit for water crossings (it serves double-duty as its raised height helps to keep the air intake out of the kicked-up dust on the trail). Front and rear off-road bumpers were bolted in place, and AEV skid plates were added to provide additional undercarriage protection. A pair of IPF-900 off-road lights improve visibility, while a 10.2-gallon AEV Fuel Caddy (located behind the exterior spare) added some range. The suspension was upgraded with a 3.5-inch lift kit with Bilstein remote reservoir shocks, and 35-inch Falken Wildpeak A/T tires (LT285/70R17) were mounted at all four corners on AEV's beadlock wheels.

Chrysler recalls 468,700 Jeep Grand Cherokees, Commanders over rollaway risk

Chrysler has issued a recall covering a combined 469,000 units of the 2005-2010 Jeep Grand Cherokee and the 2006-2010 Jeep Commander (inset). Of that number, 295,000 are in the US, roughly 33,000 in Canada and Mexico and the remainder in other markets. It seems an electrical fault in the transfer case can allow the affected SUVs to shift into neutral on their own, while an Associated Press report says that Chrysler had "found cracks in a circuit board that turns the four-wheel-drive system on and off." The issue was discovered when an owner started his car remotely and it rolled away.
Chrysler is expected to begin notifying owners in June 2013, who can then take their cars to dealers. The dealer will reflash the final drive controller free of charge. There's a bulletin from the National Highway Traffic Safety Administration below with more information.