2006 Kia Sportage Ex Sport Utility 4-door 2.7l on 2040-cars

Auto blog

Kia recalls 9,700 new Sorento models for potential front axle failures

Kia has announced a recall on the 2014 Sorento due to an issue that could lead to a broken right front driveshaft on certain models. Only models equipped with the 2.4-liter inline four-cylinder engine and front-wheel drive are affected by the campaign.
The National Highway Traffic Safety Administration says that Sorento models built between January 7 through March 12 of this year may experience broken axle shafts that could lead to loss of power or cause the vehicle to roll if parked. According to the Detroit Free Press, a total of close to 9,700 units are being recalled, but that number is closer to 9,300 for customers in the US.
Kia says that it has had one incident with an internal vehicle that experienced a separated axle shaft in addition to 10 related warranty claims, but it says no accidents or injuries have been reported. The recall campaign will begin next month. Scroll down for the NHTSA recall notice as well as an official statement from Kia.

Hyundai, Kia recall 270,000 cold-weather state vehicles over rust

Hyundai has announced plans to recall 240,000 Sonata and Azera models registered in the northern United States over corrosion caused by the use of road salt. Exposure to the salt can cause rust to form (we know, basic chemistry here), and that the corrosion can change the alignment of the rear wheels, according to Reuters.
Sonatas from the 2006 to 2010 model years, built between March 1, 2005 and January 21, 2010, and Azeras from the 2006 to 2011 model years, built between September 27, 2005 and November 22, 2010, are covered only if they were registered in the following states: Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and Washington, DC. So basically, every state from the Midwest, to the central Atlantic coast, to New England. It is unclear exactly how many Sonatas or Azeras make up the 240,000 total number.
Hyundai is also recalling 20,300 of its 2013 Santa Fe Sports, while sister company Kia is recalling 9,345 2014 Sorentos. This second recall only covers Santa Fe Sport and Sorento models with the base, 2.4-liter engine and front-wheel drive. Apparently, the front axle driveshaft can develop cracks and separate.

Kia calls reports of second US plant 'groundless'

In discussing how Kia planned to use a focus on quality to raise its brand perception and take the fight to BMW and Audi instead of Toyota, a recent article in Automotive News Europe said one of the primary constraints was production capacity; Kia simply doesn't have the ability to make enough cars to meet its aims with the plants it has.
The CEO of Hyundai-Kia is said to be reluctant to build more plants because of that focus on quality and the fact that its suppliers are stretched to the limit. The effects of that position are being felt right now with both makers losing market share, as in the case of Hyundai not being able to make enough of its Veloster Turbo for the US market.
A South Korean newspaper apparently reported last week that Kia was planning to build a second factory in Georgia with capacity for up to 150,000 units annually, and that the company would break ground as soon as this month on "KMMG2." Kia has responded to the news by saying, "The report is all groundless." The mayor of West Point, site of the current KMMG plant, said he didn't know anything about such plans, nor did the Georgia department of economic development have knowledge of a new Kia factory.